The TF-138 offers a 1 3 ⁄ 8 inch thick, super-insulated laminated door built to shield your business from every weather extreme. Highly effective Polystyrene insulation is bonded between 26-gauge substrate to provide incredible strength and thermal protection while maintaining a solid, quiet operation. Flush wood grain panels match strength with beauty.
Effective Polystyrene insulation is bonded to each steel skin, providing
strong thermal protection to the very edge of each section. - Tough PVC seal provides a continuous thermal break on all sections that reduces thermal transmission. Uniquely designed tongue and groove section joints create a weather-resistant seal against rain, snow and wind.
- Strong embossed hot-dipped galvanized steel. The pre-finished exterior and interior are then coated with a baked-on polyester primer and acrylic finish.
- 18-gauge hot-dipped galvanized recessed and concealed hardware back-up plates are carried the full height of the section, providing superior strength and durability than commonly-used hinge pads.
- End stiles are 18-gauge, hot-dipped galvanized steel.
- Our tough “U”-shaped bottom weather-seal helps protect against the elements.
*Calculated R values are in accordance with DASMA guidelines under TDS - 163.
- Our optional Polystyrene insulation reduces heat loss and features a laminated High Impact Thermal Styrene (HITS) backer.
- Windows are available in single or thermal pane glass and long panel* in either 24" x 8", 24” x 12” or 17” x 12” sizes, installed in any section.
- Exhaust ports can be installed in any section.
- Our Special Headroom Track is also available. See Below.
- 17” x 12” windows available in insulated doors only
*Long panel windows avaliable in White, Forest Green, Sandstone, and Beige.
Color(s)
 |
 |
|
 |
 |
|
 |
 |
|
 |
 |
TRACK REQUIREMENTS
CLEAR HEADROOM* Add 4“ for draw bar operator |
SIDE HEADROOM |
DEPTH INTO ROOM |
||||
2" Track |
3" Track
|
2" Track |
3" Track
|
Manual |
Motor |
|
Standard Lift |
16" |
17” |
41/2" |
5 1/2" |
Door Height + 20" |
Door Height + 50" |
High Lift
(extra clearence) |
Desired Lift + 12” |
Desired Lift + 12” |
41/2" Except as noted |
5 1/2" Except as noted |
Door Height less High lift + 24" |
If side mounted is used - 24" one side |
Low Headroom-Rear |
7” |
7” |
6” |
9” |
Door Height + 30" |
Door Height + 50" |
Vertical Lift |
2x Door Height + 12" |
2x Door Height + 12" |
41/2" Except as noted |
5 1/2" Except as noted |
18" into Room |
18" into Room |
*For large doors, call for headroom requirements.
